糖化過程完畢之后，必需要在短時間內把麥汁和麥糟別離，別離過程稱為麥汁的過濾，過濾關于釀出的酒好壞影響十分大，但許多商釀的釀酒師，只曉得過濾的大約操作框架，關于許多過濾的細節都不曉得，招致釀出的酒呈現許多不應該呈現的問題問題一：
After the saccharification process is completed, the wort and lees must be separated in a short time. The separation process is called the filtration of wort. The filtration has a great influence on the quality of the brewed wine. However, many brewers only know about the operation framework of the filtration, and the details of the filtration are not known. This leads to many problems that should not be presented in the brewed wine. 1.
假如過濾不清，其脂肪酸含量遠高于濾清的麥汁，會給啤酒的泡沫微風味帶來不良的影響問題二：
If the filtration is not clear, the content of its fatty acid is much higher than that of filtered wort, which will bring bad effects on the foam flavor of beer two:
過濾速度比擬慢，會招致多酚物質的氧化而是麥汁顏色加深，口感變差問題三：
The filtering speed is comparatively slow, which will lead to the oxidation of polyphenols, but the wort color deepens and the taste becomes worse.
洗糟過度，麥皮中的有害物質大量溶出，洗糟不完整，影響產量糖化過濾設備為防止這些問題，我們就講講過濾應該留意哪些細節商釀設備過濾如今有兩種過濾辦法，一種是自然過濾，是應用高度差產生的重力過濾；另外一種設備是抽濾，即應用泵抽麥汁過濾，這里留意假如廠家給你裝置的是抽濾，一定要廠家給你裝置均衡罐。由于假如沒有均衡罐，泵直接抽糟層，一旦操作不當或者正常的糟層壓實，很有可能把過濾篩板抽彎！其他兩種過濾辦法留意點一樣。
In order to prevent these problems, we should pay attention to the details of commercial brewing equipment filtration. One is natural filtration, which is gravity filtration caused by the difference of height; the other is pumping filtration, which is the application of pump-pumped wort filtration. Note that if the manufacturer gives you the device is the drainage filter, the manufacturer must give you the device equalization tank. Because if there is no balancing tank, the pump directly sucks the layer, once the operation is improper or the normal layer is compacted, it is very likely that the filter sieve plate will be bent! The other two central filtering methods are the same.
留意一：檢查過濾板能否鋪平壓緊，進醪前一定要泵入78℃熱水直過濾板，目的一是掃除管和篩底的空氣，二是構成水的緩沖層，避免麥醪直接砸到過濾篩板上，把篩板堵死。
Note 1: Check whether the filter plate can be paved and compacted. Before mashing, the hot water must be pumped into the filter plate at 78 C until the filter plate. The purpose is to clean the air in the pipe and the bottom of the screen. The second is to form a buffer layer of water, so as to avoid the wheat mash directly hitting the filter plate and blocking the screen plate.
留意二：在泵醪期間，糖化鍋的攪拌器要不時運動以保證得到平均的醪液。
Note 2: During the mashing period of the pump, the agitator of the saccharifying pot should move from time to time to ensure an average mash.
留意三：過濾時溫度盡量堅持在76℃~78℃，溫度低，麥汁的粘性大，過濾速度太慢，溫度太高，會招致可能沒有完成糖化的淀粉不能繼續糖化。
Note 3: When filtering, the temperature should be as high as possible from 76 78 C. Low temperature, high viscosity of wort, slow filtration speed and high temperature will cause starch that may not have completed saccharification to continue saccharification.
留意四：開端過濾階段，一定要防止過濾過快，由于開端過濾過快，會由于吸力大，使糟層壓緊，失去浸透性而難以過濾留意五：頭道麥汁的濃度和體積直接或者間接丈量出來，然后計算洗糟水的體積留意六：洗糟時，洗糟水應吞沒糟層，盡量避免氧化留意七：總過濾時間3h以內以上是
全自動涼茬機廠家為大家介紹的相關內容，本文來源：http://bumge.comPay attention to four: at the beginning of the filtration stage, we must prevent filtering too fast, because the beginning of the filtration is too fast, will be due to suction, so that the dregs are compacted, loss of permeability and difficult to filter attention 5: the concentration and volume of wort in the first passage are measured directly or indirectly, and then calculate the volume of the dregs washing water to pay attention to six: when washing the dregs, the dregs washing water should swallow the dregs layer, try to avoid oxidation to pay attention to seven: The filter time is less than 3 hours. This article is from http://bumge.com.
自動售酒機 2024-07-25 
